Had anyone studied either of these three--the great elms in the Out-park, or the thin twisted screen of hedge, or the red-tile roof, and the yellow stubble behind it on the hill--he might have found material for a picture in each. There was, in truth, in each far more than anyone could put into a picture, or than anyone could put into a book; for the painter can but give one aspect of one day, and the writer a mere catalogue of things; but Nature refreshes the reality every day with different tints, and as it were new ideas, so that, although it is always there, it is never twice the same. Over that stubble on the hill there were other hills, and among these a combe or valley, in which stood just such another farm-house, but differently placed, with few trees, and those low, somewhat bare in its immediate surroundings, but above, on each side, close at hand, sloping ramparts of green turf rising high, till the larks that sang above seemed to sing in another land, like that found by Jack when he clomb the beanstalk. Along this combe was a cover of gorse, and in spring there was a mile of golden bloom, richer than gold in colour, leading like a broad highway of gold down to the house. From those ramparts in high summer--which is when the corn is ripe and the reapers in it--there could be seen a slope divided into squares of varied grain. This on the left of the fertile undulation was a maize colour, which, when the sunlight touched it, seemed to have a fleeting hue of purple somewhere within. There is no purple in ripe wheat visible to direct and considering vision; look for it specially, and it will not be seen. Purple forms no part of any separate wheat-ear or straw; brown and yellow in the ear, yellow in the upper part of the straw, and still green towards the earth. But when the distant beams of sunlight travelling over the hill swept through the rich ripe grain, for a moment there was a sense of purple on the retina. Beyond this square was a pale gold piece, and then one where the reapers had worked hard, and the shocks stood in diagonal rows; this was a bronze, or brown and bronze, and beside it was a green of clover.

Farther on, the different green of the hill turf, and white sheep, feeding in an extended crescent, the bow of the crescent gradually descending the sward. The hills of themselves beautiful, and possessing views which are their property and belong to them--a twofold value. The woods on the lower slopes full of tall brake fern, and holding in their shadowy depths the spirit of old time. In the woods it is still the past, and the noisy mechanic present of this manufacturing century has no place. Enter in among the round-boled beeches which the squirrels rush up, twining round like ivy in ascent, where they nibble the beech-nuts forty feet aloft, and let the husks drop to your feet; where the wood-pigeon sits and does not move, safe in the height and thickness of the spray. There are jew-berries or dew-berries on a bramble-bush, which grows where the sunlight and rain fall direct to the ground, unchecked by boughs. They are full of the juice of autumn, black, rich, vine-like, taken fresh from the p.r.i.c.kly bough. Low down in the hollow is a marshy spot, sedge-grown, and in the sedge lie yellow leaves of willow already fallen. Here in the later months will come a woodc.o.c.k or two, with feathers so brown and leaf-like of hue and markings that the plumage might have been printed in colours from brown leaves of beech. No springes are set for the woodc.o.c.ks now, but the markings are the same on the feathers as centuries since; the brown beech-leaves lie in the dry hollows the year through just as they did then; the large dew-berries are as rich; and the nuts as sweet. It is the past in the wood, and Time here never grows any older. Could you bring back the red stag--as you may easily in fancy--and place him among the tall brake, and under the beeches, he should not know that a day had gone by since the stern Roundheads shot down the last of his race hereabouts in Charles I.'s days. For the leaves are turning as they turned then to the altered colour of the sun's rays as he declines in his noonday arch, lower and lower every day; his rays are somewhat yellower than in dry hot June; a little of the tint of the ripe wheat floats in the sunshine. To this the woods turn. First, the nut-tree leaves drop, and the green brake is quickly yellow; the slender birch becomes lemon on its upper branches; the beech reddens; by-and-by the first ripe acorn falls, and there's as much cawing of the rooks in the oaks at acorn-time as at their nests in the elms in March.

All these things happened in the old, old time before the red stags were shot down; the leaves changed as the sunbeams became less brilliantly white; the woodc.o.c.ks arrived; the mice had the last of the acorns which had fallen, and which the rooks and jays and squirrels had spared for them after feasting to the full of their greediness. This ancient oak, whose thick bark, like cast-iron for ruggedness at the base, has grown on steadily ever since the last deer bounded beneath it, utterly heedless of the noisy rattle of machinery in the northern cities, unmoved by any shriek of engine, or hum, or flapping of loose belting, or any volume of smoke drifting into the air--I wish that the men now serving the great polished wheels, and works in iron and steel and bra.s.s, could somehow be spared an hour to sit under this ancient oak in Thardover South Wood, and come to know from actual touch of its rugged bark that the past is living now, that Time is no older, that Nature still exists as full as ever, and to see that all the factories of the world have made no difference, and therefore not to pin their faith to any theory born and sprung up among the crush and pale-faced life of modern time; but to look for themselves at the rugged oak-bark, and up to the sky above the highest branches, and to take an acorn and consider its story and possibilities, and to watch the sly squirrel coming down, as they sit quietly, to play almost at their feet. That they might gather to themselves some of the leaves--mental and spiritual leaves--of the ancient forest, feeling nearer to the truth and soul, as it were, that lives on in it. They would feel as if they had got back to their original existence, and had become themselves, as they ought to be, could they live such life, untouched by artificial care. Then, how hurt they would be if any proposed to cut down that oak; if any proposed the felling of the forest, and the death of its meaning. It would be like a blow aimed at themselves. No picture that could be bought at a thousand guineas could come near that ancient oak; but you can carry away the memory of it, the picture and thought in your mind for nothing. If the oak were cut down, it would be like thrusting a stick through some valuable painting on your walls at home.

The common below the South Wood, even James Thardover with all his desire for improvement could not do much good with; the soil, and the impossibility of getting a fall for draining, all checked effort there. A wild, rugged waste, you say, at first, glancing at the rushes, and the gaunt signpost standing up among them, the anthills, and thistles. Thistles have colour in their bloom, and the p.r.i.c.kly leaves are finely cut; rushes--green rushes--are notes of the season, and with their slender tips point to the days in the book of the year; they are brown now at the tip, and some bent downwards in an angle. The brown will descend the stalk till the snipes come with grey-gra.s.s colours in their wings. But all the beatings of the rain will not cast the rushes utterly down; they will send up fresh green successors for the spring, for the cuckoo to float along over on his way to the signpost, where he will perch a few minutes, and call in the midst of the wilderness. There, too, the lapwings leave their eggs on the ground among the rushes, and rise, and complainingly call. The warm showers of June call up the iris in the corner where the streamlet widens, and under the willows appear large yellow flowers above the flags. Pink and white blossom of the rest-harrow comes on bushy plants where the common is dry, and there is heath, and heather, and fern. The waste has its treasures too--as the song-thrush has his in the hawthorn bush--its treasures of flowers, as the wood its beauties of tree and leaf, and the hills their wheat.

The ring-fence goes farther than this; it encloses the living creatures, yet without confining them. The wing of the wood-pigeon, as the bird perches, forms a defined curve against its body. The forward edge of the wing--its thickest part--as it is pressed to its side, draws a line sweeping round--a painter's line. How many wood-pigeons are there in the South Wood alone, besides the copses and the fir-plantations? How many turtle-doves in spring in the hedges and outlying thickets, in summer among the shocks of corn?

And all these are his--the Squire's--not in the sense of possession, for no true wild creature was ever anyone's yet; it would die first; but still, within his ring-fence, and their destinies affected by his will, since he can cut down their favourite ash and hawthorn, or thin them with shot. Neither of which he does. The robin, methinks, sings sweetest of autumn-tide in the deep woods, when no other birds speak or trill, unexpectedly giving forth his plaintive note, complaining that the summer is going, and the time of love, and the sweet cares of the nest; telling you that the berries are brown, the dew-berries over-ripe, and dropping of over-ripeness like dew as the morning wind shakes the branch; that the wheat is going to the stack, and that the rusty plough will soon be bright once more by the attrition of the earth.

Many of them sing thus in the South Wood, yet scarce any two within sound of each other, for the robin is jealous, and likes to have you all to himself as he tells his tale. Song-thrushes--what ranks of them in April; larks, what hundreds and hundreds of them on the hills above the green wheat; finches of varied species; blackbirds; nightingales; crakes in the meadows; partridges; a whole page might be filled merely with their names.

These, too, are in the ring-fence with the hills and woods, the yellow iris of the common, and the red-roofed farm-houses. Besides which, there are beings infinitely higher--namely, men and women in village and hamlet, and more precious still, those little children with hobnail boots and clean jackets and pinafores, who go a-blackberrying on their way to school. All these are in the ring-fence. Upon their physical destinies the Squire can exercise a powerful influence, and has done so, as the school itself testifies.

Now, is not a large estate a living picture? Or rather, is it not formed of a hundred living pictures? So beautiful it looks, its hills, its ripe wheat, its red-roofed farm-houses, and acres upon acres of oaks; so beautiful, it must be valuable--most valuable; it is visible, tangible wealth. It is difficult to disabuse anyone's mind of that idea; yet, as we have seen, with all the skill, science, and expenditure Thardover could bring to bear upon it, all his personal effort was in vain. It was a possession, not a profit.

Had not James Thardover's ancestors invested their wealth in building streets of villas in the outskirts of a great city, he could not have done one-fifth what he had. Men who had made their fortunes in factories--the noisy factories of the present century--paid him high rents for these residences; and thus it was that the labour and time of the many-handed operatives in mill, factory, and workshop really went to aid in maintaining these living pictures. Without that outside income the Squire could not have reduced the rents of his tenants, so that they could push through the depression; without that outside income he could not have drained the lands, put up those good buildings, a.s.sisted the school, and in a hundred ways helped the people. Those who watched the polished machinery under the revolving shaft, and tended the loom, really helped to keep the beauties of South Wood, the grain-grown hills, the flower-strewn meadows. These were so beautiful, it seemed as if they must represent money--riches; but they did not. They had a value much higher than that. As the spring rises in the valley at the foot of the hills and slowly increases till it forms a river, to which ships resort, so these fields and woods, meads and brooks, were the source from which the city was derived. If the operative in the factory, or tending the loom, had traced his descent, he would have found that his grandfather, or some scarcely more remote ancestor, was a man of the land. He followed the plough, or tended the cattle, and his children went forth to earn higher wages in the town. For the hamlet and the outlying cottage are the springs whence the sinew and muscle of populous cities are derived. The land is the fountain-head from which the spring of life flows, widening into a river. The river at its broad mouth disdains the spring; the city in its immensity disdains the hamlet and the ploughman. Yet if the spring ceased, the ships could not frequent the river; if the hamlet and the ploughman were wiped out by degrees, the city must run dry of life. Therefore the South Wood and the park, the hamlet and the fields, had a value no one can tell how many times above the actual money rental, and the money earned by the operatives in factory and workshop could not have been better expended than in supporting it.

But it had another value still--which they too helped to sustain--the value of beauty. Parliament has several times intervened to save the Lake District from the desecrating intrusion of useless railways. So, too, the beauty of these woods, and grain-grown hills, of the very common, is worth preservation at the hands and votes of the operatives in factory and mill. If a man loves the brick walls of his narrow dwelling in a close-built city, and the flowers which he has trained with care in the window, how much more would he love the hundred living pictures like those round about Thardover House! After any artificer had once seen such an oak and rested under it, if any threatened to cut it down, he would feel as if a blow had been delivered at his heart. His efforts, therefore, should be not to destroy these pictures, but to preserve them. All the help that they can give is needed to a.s.sist a King of Acres in his struggle, and the struggle of the farmers and labourers--equally involved--against the adverse influences which press so heavily on English agriculture.

THE STORY OF SWINDON

We have all of us pa.s.sed through Swindon Station, whether _en route_ to Southern Wales, to warm Devon--the fern-land--to the Channel Islands, or to Ireland. The ten minutes for refreshment, now in the case of certain trains reduced to five, have made thousands of travellers familiar with the name of the spot. Those who have not actually been there can recall to memory a shadowy tradition which has grown up and propagated itself, that here the soup skins the tongue, and that generally it is a near relative of the famous 'Mugby Junction.' Those who have been there retain at least a confused recollection of large and lofty saloons, velvet sofas, painted walls, and long semicircular bars covered with glittering gla.s.ses and decanters. Or it may be that the cleverly executed silver model of a locomotive under a gla.s.s case lingers still in their memories. At all events Swindon is a well-known oasis, familiar to the travelling public. Here let us do an act of justice.

Much has been done of late to ameliorate many of the inst.i.tutions which formerly led to bitter things being said against the place.

The soup is no longer liquid fire, the beer is not lukewarm, the charges are more moderate; the lady manager has succeeded in subst.i.tuting order for disorder, comfort and attention in place of lofty disdain. Pa.s.sengers have not got to cross the line for a fresh ticket or to telegraph; the whole place is reformed. So much the better for the traveller. But how little do these birds of pa.s.sage imagine the varied interest of the strange and even romantic story which is hidden in this most unromantic spot, given over, as it seems, to bricks and mortar!

Not that it ever had a history in the usual sense. There is but a faint, dim legend that the great Sweyn halted with his army on this hill--thence called Sweyn's dune, and so Swindon. There is a family here whose ancestry goes back to the times of the Vikings; which was in honour when Fair Rosamond bloomed at Woodstock; which fought in the great Civil War. Nothing further. The real history, written in iron and steel, of the place began forty years ago only. Then a certain small party of gentlemen sat down to luncheon on the greensward which was then where the platform is now. The furze was in blossom around them; the rabbits frisked in and out of their burrows; two or three distant farm-houses, one or two cottages, these were all the signs of human habitation, except a few cart-ruts indicating a track used for field purposes. There these gentlemen lunched, and one among them, ay, two among them, meditated great things, which the first planned, and the second lived to see realize the most sanguine antic.i.p.ations. These two gentlemen were Isambard Brunel and Daniel Gooch. Driven away from the original plan, which was to follow the old coach-road, they had come here to survey and reconnoitre a possible track running in the valley at the northern edge of the great range of Wiltshire Downs. They decided that here should be their junction and their workshop. Immense sacrifices, enormous expenditure, the directors of the new railway incurred in their one great idea of getting it finished! They could not stay to cart the earth from the cuttings to the places where it was required for embanking, so where they excavated thousands of tons of clay they purchased land to cast it upon out of their way; and where they required an embankment they purchased a hill, and boldly removed it to fill up the hollow. They could not stay for the seasons, for proper weather to work in, and in consequence of this their clay embankment, thrown up wet and saturated, swelled out, bulged at the sides, and could not be made stable, till at last they drove rows of piles on each side, and chained them together with chain-cables, and so confined the slippery soil. They drove these piles, tall beech-trees, 20 feet into the earth, and at this day every train pa.s.ses over tons of chain-cables hidden beneath the ballast. The world yet remembers the gigantic cost of the Box Tunnel, and how heaven and earth were moved to get the line open; and at last it was open, but at what a cost!--a cost that hung like a millstone round the neck of the company, till a man rose into power who had the talent of administration, and that man was the very companion of Brunel whom we saw lunching among the furze-bushes. Reckless as the expenditure was, one cannot but admire the determination which overcame every obstacle. For the great line a workshop was needed, and that workshop was built at Swindon. The green fields were covered with forges, the hedges disappeared to make way for cottages for the workmen. The workmen required food--tradesmen came and supplied that food--and Swindon rose as Chicago rose, as if by magic. From that day to this additions have been made, and other departments concentrated upon this one spot, till at the present time the factory covers a s.p.a.ce equal to that of a moderate farm, and employs nearly four thousand workmen, to whom three hundred thousand pounds are yearly paid, whereby to purchase their daily bread. But at that early stage the difficulty was to find experienced workmen, and still greater to discover men who could superintend them. For these it was necessary to go up into the shrewd North, which had already foreseen the demand that must arise, and had partially educated her children in the new life that was about to dawn on the world; and so it is that to this time the names of those who are in authority over this army of workers carry with them in their sound a strong flavour of the heather and the brae, and seem more in accordance with ideas of 'following the wild deer'

than of a dwelling in the midst of the clangour and smoke.

All these new inhabitants of the hitherto deserted fields had to be lodged, and in endeavouring to solve this problem the company were induced to try an experiment which savoured not a little of communism, though not so intended. A building was erected which was locally called the 'barracks,' and it well deserved the name, for at one time as many as perhaps five hundred men found shelter in it. It was a vast place, with innumerable rooms and corridors. The experiment did not altogether answer, and was in time abandoned, when the company built whole streets, and even erected a covered market-place for their labourers. They went further, and bore the chief expense in building a church. A reading-room was started, and grew and grew till a substantial place was required for the accommodation of the members. Finally, the 'barracks' was converted into a place of worship for a Dissenting body, and a grand hall it afforded when the interior was removed and only the sh.e.l.l left. But by this time vast changes had taken place, and great extensions had arisen through private energy. This land was the poorest in the neighbourhood; low-lying, shallow soil on top of an endless depth of stiff clay, worthless for arable purposes, of small value for pasture, covered with furze, rushes, and rowen; so much so that when a certain man with a little money purchased a good strip of it, he was talked of as a fool, and considered to have committed a most egregious error. How vain is human wisdom! In a few years the railway came. Land rose in price, and this very strip brought its owner thousands; so that the fool became wise, and the wise was deemed of no account. Private speculators, seeing the turn things were taking, ran up rows of houses; building societies stepped in and laid out streets; a whole town seemed to start into being at once. Still the company continued to concentrate their works at the junction, and at last added the culminating stroke by bringing the carriage department here, which was like planting a new colony. A fresh impulse was given to building; fresh blocks and streets arose; companies were formed to burn bricks--one of these makes bricks by steam, and can burn a quarter of a million at once in their kiln.

This in a place where previously the rate of building was five new houses in twenty years! Sanitary districts were mapped out; boards of control elected; gas companies; water companies--who brought water out of the chalk hills three miles distant: all the distinctive characteristics of a city arose into being. Lastly came a sewage farm, for so great was the sewage that it became a burning question how to dispose of it, and on this sewage farm some most extraordinary results have been obtained, such as mangolds with leaves four feet in length--a tropical luxuriance of growth. One postman had sufficed, then two, then three, till a strong staff had to be organized, in regular uniform, provided with bull's-eye lanthorns to pick their way in and out of the dark and dirty back-streets. One single constable had sufficed, and a dark hole had done duty as a prison. Now a superintendent and other officers, a full staff, and a complete police-station, with cells, justice-room, all the paraphernalia were required; and so preposterous did this seem to other towns, formerly leading towns in the country, but which had remained stagnant while Swindon went ahead, that they bitterly resented the building, and satirized it as a 'Palace of Justice,' though, in good truth, sorely needed. A vast corn exchange, a vaster drill-hall for the workmen--who had formed a volunteer corps--to drill in, chapels of every description, and some of really large size--all these arose.

The little old town on the hill a mile from the station felt the wave of progress strongly. The streets were paved; sewers driven under the town at a depth of 40 feet through solid stone, in order to dispose of the sewage on a second sewage farm of over 100 acres.

Shops, banks, and, above all, public-houses, abounded and increased apace, especially in the new town, where every third house seemed to be licensed premises. The cart-track seen by the luncheon-party in the furze was laid down and macadamized, and a street erected, named after the finest street in London, full of shops of all descriptions. Every denomination, from the Plymouth Brethren to the Roman Catholics, had their place of worship. Most of the tradesmen had two branches, one in the upper and one in the lower town, and the banks followed their example. Not satisfied with two railways, two others are now in embryo--one a link in the long-talked-of through communication between North and South, from Manchester to Southampton, the other a local line with possible extensions. A population of barely 2,000 has risen to 15,000, and this does not nearly represent the real number of inhabitants, for there is a large floating population, and, in addition, five or six villages surrounding the town are in reality merely suburbs, and in great part populated by men working in the town. These villages have shared in the general movement, and some of them have almost trebled in size and importance. This population is made up of the most incongruous elements: labouring men of the adjacent counties who have left the plough and the sickle for the hammer and the spade; Irish in large numbers; Welshmen, Scotch, and North of England men; stalwart fellows from York and places in a similar lat.i.tude. Yet, notwithstanding all the building that has been going on, despite the rush of building societies and private speculators, the cry is still, 'More bricks and mortar,' for there exists an enormous amount of overcrowding. The high rents are almost prohibitory, and those who take houses, underlet them and sublet them, till in six rooms three families may be living. The wages are good, ranging from 18s.

for common labourers to 30s., 36s., 40s., and more for skilled mechanics, and the mode in which they live affords an ill.u.s.trative contrast to the agricultural population immediately surrounding the place. As if to complete the picture, that nothing might be wanting, a music-hall has been opened, where for threepence the workman may listen to the dulcet strains of 'London artistes' while he smokes his pipe.

Can a more striking, a more wonderful and interesting spectacle be seen than this busy, Black-Country-looking town, with its modern a.s.sociations, its go-ahead ways, in the midst of a purely agricultural country, where there are no coal or iron mines, where in the memory of middle-aged men there was nothing but pasture-fields, furze, and rabbits? In itself it affords a perfect epitome of the spirit of the nineteenth century.

And much, if not all, of this marvellous transformation, of this abounding life and vigorous vitality, is due to the energy and the forethought, the will of one man. It is notorious that the Swindon of to-day is the creation of the companion of Brunel at the lunch in the furze-bushes. Sir Daniel Gooch has had a wonderful life.

Beginning literally at the beginning, he rose from stage to stage, till he became the responsible head of the vast company in whose service he had commenced life. In that position he did not forget the place where his early years were pa.s.sed, but used his influence to enrich it with the real secret of wealth, employment for the people. In so doing, time has proved that he acted for the best interests of the company, for, apart from monetary matters, the ma.s.s of workmen a.s.sembled at this spot are possessed of overwhelming political power, and can return the man they choose to Parliament.

Thus the company secures a representative in the House of Commons.

Among the inst.i.tutions which the railway company fostered was the primitive reading-room which has been alluded to. Under their care this grew and grew, until it became a Mechanics' Inst.i.tute, or, rather, a department of science and art, which at the present day has an intimate connection with South Kensington. Some hundred prizes are here annually distributed to the numerous students, both male and female, who can here obtain the very best instruction, at the very smallest cost, in almost every branch of learning, from sewing to shorthand, from freehand drawing to algebra and conic sections. On one occasion, while distributing the prizes to the successful compet.i.tors, Sir Daniel Gooch laid bare some of his early struggles as an incentive to the youth around him. He admitted that there was a time, and a dark hour, when he all but gave up hopes of ultimate success, when it seemed that the dearest wish of his heart must for ever go without fulfilment. In this desponding mood he was slowly crossing a bridge in London, when he observed an inscription upon the parapet--_Nil Desperandum_ (Never despair). How he took heart at this as an omen, and went forth and persevered till----The speaker did not complete the sentence, but all the world knows what ultimately happened, and remembers the man who laid the first Atlantic cable. The great lesson of perseverance, of patience, was never drawn with better effect.

In the Eastern tales of magicians one reads of a town being found one day where there was nothing but sand the day before. Here the fable is fact, and the potent magician is Steam. Here is, perhaps, the greatest temple that has ever been built to that great G.o.d of our day. Taking little note of its immense extent, of the vast walls which enclose it, like some fortress, of the tunnel which gives entrance, and through which three thousand workmen pa.s.s four times a day, let us enter at once and go straight to the manufacture of those wheels and tires and axles of which we have heard so much since the tragedy at Shipton. To look at a carriage-wheel, the iron carriage-wheel, one would imagine that it was all one piece, that it was stamped out at a blow, so little sign is there of a junction of parts. The very contrary is the fact: the wheel is made of a large number of pieces of iron welded together, and again and again welded together, till at last it forms one solid h.o.m.ogeneous ma.s.s. The first of these processes consists in the manufacture of the spokes, which are made out of fine iron. The spoke is made in two pieces, at two different forges, and by two distinct gangs of men. A third forge and a third gang are constantly employed in welding these two detached parts in one continuous piece, forming a spoke. One of these parts resembles a [T] with the downward stroke very short, and the cross stroke at the top slightly bent, so as to form a section of a curve. The other piece is about the same length, but rather thicker, and at its larger end somewhat wedge-shaped. This last piece forms that part of the spoke which goes nearest to the centre of the wheel. These two parts, when completed, are again heated to a red heat, and in that ductile state hammered with dexterous blows into one, which then resembles the same letter [T], only with the downward stroke disproportionately long. Eight or more of these spokes, according to the size of the wheel, and whether it is intended for a carriage, an engine, or tender, are then arranged together on the ground, so that the wedge-shaped ends fit close together, and in that position are firmly fixed by the imposition above them of what is called a 'washer,' a flat circular piece of iron, which is laid red-hot on the centre of the embryo wheel, and there hammered into cohesion. The wheel is then turned over, and a second 'washer' beaten on, so that the partially molten metal runs, and joins together with the particles of the spokes, and the whole is one ma.s.s. In the ordinary cart-wheel or gig-wheel the spokes are placed in mortise-holes made in a solid central block; but in this wheel before us, the ends of the spokes, well cemented together by the two washers, form the central block or boss. The ends of the spokes do not quite touch each other, and so a small circular s.p.a.ce is left which is subsequently bored to fit the axle. The wheel now presents a curiously incomplete appearance, for the top strokes of the [T]'s do not touch each other. There is a s.p.a.ce between each, and these s.p.a.ces have now to be filled with pieces of red-hot iron well welded and hammered together. To the uninitiated it would seem that all this work is superfluous; that the wheel might be made much more quickly in two or three pieces, instead of all these, and that it would be stronger. But the practical men engaged in the work say differently. It is their maxim that the more iron is hammered, the stronger and better it becomes; therefore all this welding adds to the strength of the wheel. In practice it is found quicker and more convenient to thus divide the labour than to endeavour to form the wheel of fewer component parts. The wheel is now taken to the lathe, and a portion is cut away from its edge, till a groove is left so as to dovetail into the tyre.

The tyres, which are of steel, are not made here; they come ready to be placed upon the wheel, and some care has to be taken in moving them, for, although several inches in thickness and of enormous strength, it has occasionally happened that a sudden jar from other solid bodies has fractured them. One outer edge of the tyre is prolonged, so to say, and forms the projecting f.l.a.n.g.e which holds the rails and prevents the carriage from running off the road. So important a part requires the best metal and the most careful manufacture, and accordingly no trouble or expense is spared to secure suitable tyres. One of the inner edges of the tyre, on the opposite side to the f.l.a.n.g.e, is grooved, and this groove is intended to receive the edge of the wheel itself; they dovetail together here. The tyre is now made hot, and the result of that heating is an expansion of the metal, so that the circle of the tyre becomes larger. The wheel is then driven into the tyre, which fits round it like a band. As it grows cool the steel tyre clasps the iron wheel with enormous force, and the softer metal is driven into the groove of the steel. But this is not all. The wheel is turned over, and the iron wheel is seen to be some little distance sunk, as it were, beneath the surface of the tyre. Immediately on a level with the iron wheel there runs round the steel tyre another deeper groove.

The wheel is again heated--not to redness, for the steel will not bear blows if too hot--and when the tyre is sufficiently warm, a long, thin strip of iron is driven into this groove, and so shuts the iron wheel into the tyre as with a continuous wedge. Yet another process has to follow--yet another safeguard against accident. The tyre, once more heated, is attacked with the blows of three heavy sledge-hammers, wielded by as many stalwart smiths, and its inner edge, by their well-directed blows, bent down over the narrow band of iron, or continuous wedge, so that this wedge is closed in by what may be called a continuous rivet. The wheel is now complete, so far as its body is concerned, and to look at, it seems very nearly impossible that any wear or tear, or jar or accident, could disconnect its parts--all welded, overlapped, dovetailed as they are. Practically it seems the perfection of safety; nor was it to a wheel of this character that _the_ accident happened. The only apparent risk is that there may be some slight undiscovered flaw in the solid steel which, under the pressure of unforeseen circ.u.mstances, may give way. But the whole design of the wheel is to guard against the ill-effects that would follow the snapping of a tyre. Suppose a tyre to 'fly'--the result would be a small crack; supposing there were two cracks, or ten cracks, the speciality of this wheel is that not one of those pieces could come off--that the wheel would run as well and as safely with a tyre cracked through in a dozen places as when perfectly sound. The reason of this is that every single quarter of an inch of the tyre is fixed irremovably to the outer edge of the iron wheel, by the continuous dovetail, by the continuous wedge, and by the continuous overlapping. So that under no condition could any portion of the tyre fly off from the wheel.

Close by this wheel thus finished upon this patent process there was an old riveted wheel which had been brought in to receive a new tyre on the new process. This old wheel aptly ill.u.s.trates the advantages of the new one. Its tyre is fixed to the wheel by rivets or bolts placed at regular intervals. Now, the holes made for these bolts to some extent weaken both tyre and wheel. The bolt is liable, with constant shaking, to wear loose. The bolt only holds a very limited area of tyre to the wheel. If the tyre breaks in two places between the bolts, it comes off. If a bolt breaks, or the tyre breaks at the bolt, it flies. The tyre is, in fact, only fixed on in spots with intervals between. The new fastening leaves no intervals, and instead of spots is fixed everywhere. This is called the Gibson process, and was invented by an employe of the company. Latterly another process has partially come into vogue, particularly for wooden wheels, which are preferred sometimes on account of their noiselessness. By this (the Mansell) process, the tyres, which are similar, are fastened to the wheels by two circular bands which dovetail into the tyre, and are then bolted to the wood.

To return to the wheel--now really and substantially a wheel, but which has still to be turned so as to run perfectly true upon the metals--it is conveyed to the wheel lathe, and affixed to what looks like another wheel, which is set in motion by steam-power, and carries our wheel round with it. A workman sets a tool to plane its edge, which shaves off the steel as if it were wood, and reduces it to the prescribed scale. Then, when its centre has been bored to receive the axle, the genesis of the wheel is complete, and it enters upon its life of perpetual revolution. How little do the innumerable travellers who are carried to their destination upon it imagine the immense expenditure of care, skill, labour, and thought that has been expended before a perfect wheel was produced.

Next in natural order come the rails upon which the wheel must run.

The former type of rail was a solid bar of iron, whose end presented a general resemblance to the letter [T], which was thick at the top and at the bottom, and smaller in the middle. It was thought that this rail was not entirely satisfactory, for reasons that cannot be enumerated here, and accordingly a patent was taken out for a rail which, it is believed, can be more easily and cheaply manufactured, with a less expenditure of metal, and which can be more readily attached to the sleepers. In reality it is designed upon the principle of the arch, and the end of these rails somewhat resembles the Greek letter [Omega], for they are hollow, and formed of a thin plate of metal rolled into this shape. Coming to this very abode of the Cyclops, the rail-mill, the first machine that appears resembles a pair of gigantic scissors, which are employed day and night in snipping off old rails and other pieces of iron into lengths suitable for the manufacture of new rails.

These scissors, or, perhaps, rather pincers, are driven by steam-power, and bite off the solid iron as if it were merely strips of ribbon. There is some danger in this process, for occasionally the metal breaks and flies, and men's hands are severely injured. At a guess, the lengths of iron for manufacture into rails may be about four feet long, and are piled up in flat pieces eight or nine inches or more in height. These pieces are carried to the furnace, heated to an intense heat, and then placed under the resistless blows of a steam-hammer, which welds them into one solid bar of iron, longer than the separate pieces were. The bar then goes back to the furnace, and again comes out white-hot. The swinging-shears seize it, and it is swung along to the rollers. These rollers are two ma.s.sive cylindrical iron bars which revolve rapidly one over the other. The end of the white-hot metal is placed between these rollers, and is at once drawn out into a long strip of iron, much as a piece of dough is rolled out under the cook's rolling-pin. It is now perfectly flat, and entirely malleable. It is returned to the furnace, heated, brought back, and placed in a second pair of rollers. This second pair have projections upon them, which so impress the flat strip of iron that it is drawn out into the required shape. The rail pa.s.ses twice through these rollers, once forwards, then backwards. Terrible is the heat in this fiery spot.

The experienced workman who guides the long red-hot rails to the mouth of the rollers is protected with a mask, with iron-shod shoes, iron greaves on his legs, an iron ap.r.o.n, and, even further, with a shield of iron. The very floor beneath is formed of slabs of iron instead of slabs of stone, and the visitor very soon finds this iron floor too hot for his feet. The perfect rail, still red-hot or nearly, is run back to the circular saw, which cuts it off in regular lengths; for it is not possible to so apportion the iron in each bundle as to form absolutely identical strips. They are proportioned so as to be a little longer than required, and then sawn off to the exact length. While still hot, a workman files the sawn ends so that they may fit together closely when laid down on the sleepers. The completed rails are then stacked for removal on trucks to their destination. The rollers which turn out these rails in so regular and beautiful a manner are driven by a pair of engines of enormous power. The huge fly-wheel is twenty feet in diameter, and weighs, with its axle, thirty-five tons. When these rails were first manufactured, the rollers were driven direct from the axle of the fly-wheel, and the rails had to be lifted right over the roller--a difficult and dangerous process--and again inserted between them on the side at which it started. Since then an improvement has been effected, by which the rails are sent backwards through the rollers, thus avoiding the trouble of lifting them over.

This is managed by reversing the motion of the rollers, which is done in an instant by means of a 'crab.'

Immediately adjacent to these rail-mills are the steam-hammers, whose blows shake the solid earth. The largest descends with the force of seventy tons, yet so delicate is the machinery that visitors are shown how the same ponderous ma.s.s of metal and the same irresistible might can be so gently administered as to crush the sh.e.l.l of a nut without injuring the kernel. These hammers are employed in beating huge ma.s.ses of iron into cranks for engines, and other heavy work which is beyond the unaided strength of man. Each of the hammers has its own steam-boiler and its furnace close at hand, and overhead there are travelling cranes which convey the metal to and fro. These boilers may be called vertical, and with the structure on which they are supported have a dome-like shape.

Hissing, with small puffs of white steam curling stealthily upwards, they resemble a group of volcanoes on the eve of an eruption. This place presents a wonderful and even terrible aspect at night, when the rail-mill and steam-hammers are in full swing. The open doors of the glaring furnaces shoot forth an insupportable beam of brilliant white light, and out from among the glowing fire comes a ma.s.sive bar of iron, hotter, whiter than the fire itself--barely to be looked upon. It is dragged and swung along under the great hammer; Thor strikes, and the metal doubles up, and bends as if of plastic clay, and showers of sparks fly high and far. What looks like a long strip of solid flame is guided between the rollers, and flattened and shaped, till it comes out a dull-red-hot rail, and the sharp teeth of the circular saw cut through it, throwing out a circle of sparks.

The vast fly-wheel whirls round endless shaftings, and drums are revolving overhead, and the ear is full of a ceaseless overpowering hum, varied at intervals with the sharp sc.r.a.ping, ringing sound of the saw. The great boilers hiss, the furnaces roar, all around there is a sense of an irresistible power, but just held in by bars and rivets, ready in a moment to rend all asunder. Ma.s.ses of glowing iron are wheeled hither and thither in wheelbarrows; smaller blocks are slid along the iron floor. Here is a heap of red-hot sc.r.a.ps hissing. A sulphurous hot smell prevails, a burning wind, a fierce heat, now from this side, now from that, and ever and anon bright streaks of light flow out from the open furnace doors, casting grotesque shadows upon the roof and walls. The men have barely a human look, with the reflection of the fire upon them; mingling thus with flame and heat, toying with danger, handling, as it seems, red-hot metal with ease. The whole scene suggests the infernal regions. A mingled hiss and roar and thud fill the building with reverberation, and the glare of the flames rising above the chimneys throws a reflection upon the sky, which is visible miles away, like that of a conflagration.

Stepping out of this pandemonium, there are rows upon rows of gleaming forges, each with its appointed smiths, whose hammers rise and fall in rhythmic strokes, and who manufacture the minor portions of the incipient locomotive. Here is a machine the central part of which resembles a great corkscrew or spiral constantly revolving. A weight is affixed to its inclined plane, and is carried up to the required height by the revolution of the screw, to be let fall upon a piece of red-hot iron, which in that moment becomes a bolt, with its projecting head or cap. Though they do not properly belong to our subject, the great marine boilers in course of construction in the adjoining department cannot be overlooked, even if only for their size--vast cylinders of twelve feet diameter. Next comes the erecting shop, where the various parts of the locomotive are fitted together, and it is built up much as a ship from the keel. These semi-completed engines have a singularly helpless look--out of proportion, without limbs, and many mere skeletons. Close by is the department where engines out of repair are made good. Some American engineer started the idea of a railway thirty feet wide, an idea which in this place is partially realized. The engine to be repaired is run on to what may be described as a turn-table resting upon wheels, and this turn-table is bodily rolled along, like a truck, with the engine on it, to the place where tools and cranes and all the necessary gear are ready for the work upon it. Now by a yard, which seems one vast a.s.semblage of wheels of all kinds--big wheels, little wheels, wheels of all sizes, nothing but wheels; past great mounds of iron, shapeless heaps of sc.r.a.p, and then, perhaps, the most interesting shop of all, though the least capable of description, is entered. It is where the endless pieces of metal of which the locomotive is composed are filed and planed and smoothed into an accurate fit; an immense building, with shafting overhead and shafting below in endless revolution, yielding an incessant hum like the sound of armies of bees--a building which may be said to have a score of aisles, up which one may walk with machinery upon either side. Hundreds of lathes of every conceivable pattern are planing the solid steel and the solid iron as if it were wood, cutting off with each revolution a more or less thick slice of the hard metal, which curls up like a shaving of deal. So delicate is the touch of some of these tools, so good the metal they are employed to cut, that shavings are taken off three or more feet long, curled up like a spiral spring, and which may be wound round the hand like string. The interiors of the cylinders, the bearings, those portions of the engines which slide one upon the other, and require the most accurate fit, are here adjusted by unerring machinery, which turns out the work with an ease and exactness which the hand of man, delicate and wonderful organ as it is, cannot reach. From the smallest fitting up to the great engine cranks, the lathes smooth them all--reduce them to the precise size which they were intended to be by the draughtsman. These cranks and larger pieces of metal are conveyed to their lathes and placed in position by a steam crane, which glides along upon a single rail at the will of the driver, who rides on it, and which handles the ma.s.sive metal almost with the same facility that an elephant would move a log of wood with his trunk. Most of us have an inherent idea that iron is exceedingly hard, but the ease with which it is cut and smoothed by these machines goes far to remove that impression.

The carriage department does not offer so much that will strike the eye, yet it is of the highest importance. To the uninitiated it is difficult to trace the connection between the various stages of the carriage, as it is progressively built up, and finally painted and gilded and fitted with cushions. Generally, the impression left from an inspection is that the frames of the carriages are made in a way calculated to secure great strength, the material being solid oak.

The brake-vans especially are made strong. The carriages made here are for the narrow gauge, and are immensely superior in every way to the old broad-gauge carriage, being much more roomy, although not so wide. Over the department there lingers an odour of wood. It is common to speak of the scented woods of the East and the South, but even our English woods are not devoid of pleasant odour under the carpenter's hands. Hidden away amongst the piles of wood there is here a triumph of human ingenuity. It is an endless saw which revolves around two wheels, much in the same way as a band revolves around two drums. The wheels are perhaps three feet in diameter, and two inches in thickness at the circ.u.mference. They are placed--one as low as the workman's feet, another rather above his head--six or seven feet apart. Round the wheels there stretches an endless narrow band of blue steel, just as a ribbon might. This band of steel is very thin, and almost half an inch in width. Its edge towards the workman is serrated with sharp deep teeth. The wheels revolve by steam rapidly, and carry with them the saw, so that, instead of the old up and down motion, the teeth are continually running one way.

The band of steel is so extremely flexible that it sustains the state of perpetual curve. There are stories in ancient chronicles of the wonderful swords of famous warriors made of such good steel that the blade could be bent till the point touched the hilt, and even till the blade was tied in a knot. These stories do not seem like fables before this endless saw, which does not bend once or twice, but is incessantly curved, and incessantly in the act of curving. A more beautiful machine cannot be imagined. Its chief use is to cut out the designs for cornices, and similar ornamental work in thin wood; but it is sufficiently strong to cut through a two-inch plank like paper. Every possible support that can be afforded by runners is given to the saw; still, with every aid, it is astonishing to see metal, which we have been taught to believe rigid, flexible as indiarubber. Adjoining are frame saws, working up and down by steam, and cutting half a dozen or more boards at the same time. It was in this department that the Queen's carriage was built at a great expenditure of skill and money--a carriage which is considered one of the masterpieces of this particular craft.

There rises up in the mind, after the contemplation of this vast workshop, with its endless examples of human ingenuity, a conviction that safety in railway travelling is not only possible, but probable, and even now on the way to us. No one can behold the degree of excellence to which the art of manufacturing material has been brought, no one can inspect the processes by which the wheel, for instance, is finally welded into one compact ma.s.s, without a firm belief that, where so much has been done, in a little time still more will be done. That safer plans, that better designs, that closer compacted forms will arise seems as certain and a.s.sured a fact as that those forms now in use arose out of the rude beginnings of the past; for this great factory, both in its machine-tools and in its products, the wheels and rails and locomotives, is a standing proof of the development which goes on in the mind of man when brought constantly to bear upon one subject. As with the development of species, so it is with that of machinery: rude and more general forms first, finer and more specialized forms afterwards. There is every reason to hope, for this factory is a proof of the advance that has been made. It would seem that the capability of metal is practically infinite.

But what an enormous amount of labour, what skill, and what complicated machinery must be first employed before what is in itself a very small result can be arrived at! In order that an individual may travel from London to Oxford, see what innumerable conditions have to be fulfilled. Three thousand men have to work night and day that we may merely seat ourselves and remain pa.s.sive till our destination is reached.

This small nation of workers, this army of the hammer, lathe, and drill, affords matter for deep meditation in its sociological aspect. Though so numerous that no one of them can be personally acquainted with more than a fractional part, yet there is a strong _esprit de corps_, a spirit that ascends to the highest among them; for it is well known that the chief manager has a genuine feeling of almost fatherly affection for these his men, and will on no account let them suffer, and will, if possible, obtain for them every advantage. The influence he thereby acquires among them is princ.i.p.ally used for moral and religious ends. Under these auspices have arisen the great chapels and places of worship of which the town is full. Of the men themselves, the majority are intelligent, contrasting strongly with the agricultural poor around them, and not a few are well educated and thoughtful. This gleaning of intellectual men are full of social life, or, rather, of an interest in the problems of social existence. They eagerly discuss the claims of religion _versus_ the allegations of secularism; they are shrewd to detect the weak points of an argument; they lean, in fact, towards an eclecticism: they select the most rational part of every theory. They are full of information on every subject--information obtained not only from newspapers, books, conversation, and lectures, but from travel, for most have at least been over the greater part of England. They are probably higher in their intellectual life than a large proportion of the so-called middle cla.s.ses. One is, indeed, tempted to declare, after considering the energy with which they enter on all questions, that this cla.s.s of educated mechanics forms in reality the protoplasm, or living matter, out of which modern society is evolved. The great and well-supplied reading-room of the Mechanics' Inst.i.tute is always full of readers; the library, now an extensive one, is constantly in use. Where one book is read in agricultural districts, fifty are read in the vicinity of the factory. Social questions of marriage, of religion, of politics, sanitary science, are for ever on the simmer among these men. It would almost seem as if the hammer, the lathe, and the drill would one day bring forth a creed of its own. A characteristic of all cla.s.ses of these workmen is their demand for meat, of which great quant.i.ties are consumed. Nor do they stay at meat alone, but revel in fish and other luxuries at times, though the champagne of the miner is not known here. Notwithstanding the number of public-houses, it is a remarkable fact that there is very little drunkenness in proportion to the population, few crimes of violence, and, what is more singular still, and has been often remarked, very little immorality. Where there are some hundreds, perhaps thousands, of young uneducated girls, without work to occupy their time, there must of course exist a certain amount of lax conduct; but never, or extremely rarely, does a girl apply to the magistrates for an affiliation order, while from agricultural parishes such applications are common. The number of absolutely immoral women openly practising infamy is also remarkably small.

There was a time when the workmen at this factory enjoyed an unpleasant notoriety for mischief and drunkenness, but that time has pa.s.sed away, a most marked improvement having taken place in the last few years.

There appears, however, to be very little prudence amongst them. The man who receives some extra money for extra work simply spends it on unusual luxuries in food or drink; or, if it be summer, takes his wife and children a drive in a hired conveyance. To this latter there can be no objection; but still, the fact remains prominent that men in the receipt of good wages do not save. They do not put by money; this is, of course, speaking of the majority. It would almost seem to be a characteristic of human nature that those who receive wages for work done, so much per week or fortnight, do not contract saving habits. The small struggling tradesman, whose income is very little more than that of the mechanic, often makes great exertions and practises much economy to put by a sum to a.s.sist him in difficulty or to extend his business. It may be that the very certainty of the wages acts as a deterrent--inasmuch as the mechanic feels safe of his weekly money, while the shopkeeper runs much risk.

It is doubtful whether mechanics with good wages save more than agricultural labourers, except in indirect ways--ways which are thrust upon them. First of all, there is the yard club, to which all are compelled to pay by their employers, the object being to provide medical a.s.sistance in case of sickness. This is in some sense a saving. Then there are the building societies, which offer opportunities of possessing a house, and the mechanic who becomes a member has to pay for it by instalments. This also may be called an indirect saving, since the effect is the same. But of direct saving--putting money in a bank, or investing it--there is scarcely any. The quarter of a million annually paid in wages mostly finds its way into the pockets of the various trades-people, and at the end of the year the mechanic is none the better off. This is a grave defect in his character. Much of it results from a generous, liberal disposition: a readiness to treat a friend with a drink, to drive the family out into the country, to treat the daughter with a new dress. The mechanic does not set a value upon money in itself.

The effect of the existence of this factory upon the whole surrounding district has been marked. A large proportion of the lower cla.s.s of mechanics, especially the factory labourers, are drawn from the agricultural poor of the adjacent villages. These work all day at the factory, and return at night. They daily walk great distances to secure this employment: three miles to and three miles back is common, four miles not uncommon, and some have been known to walk six or twelve miles per day. These carry back with them into the villages the knowledge they insensibly acquire from their better-informed comrades, and exhibit an independent spirit.

For a radius of six miles round the poorer cla.s.s are better informed, quicker in perception, more ready with an answer to a question, than those who dwell farther back out of the track of modern life. Wages had materially risen long before the movement among the agricultural labourers took place.

Where there was lately nothing but furze and rabbits there is now a busy human population. Why was it that for so many hundreds of years the population of England remained nearly stationary? and why has it so marvellously increased in this last forty years? The history of this place seems to answer that interesting question. The increase is due to the facilities of communication which now exist, and to the numberless new employments in which that facility of communication took rise, and which it in turn adds to and fosters.

UNEQUAL AGRICULTURE

In the way of sheer, downright force few effects of machinery are more striking than a steam-ploughing engine dragging the shares across a wide expanse of stiff clay. The huge engines used in our ironclad vessels work with a graceful ease which deceives the eye; the ponderous cranks revolve so smoothly, and shine so brightly with oil and polish, that the mind is apt to underrate the work performed. But these ploughing engines stand out solitary and apart from other machinery, and their shape itself suggests crude force, such force as may have existed in the mastodon or other unwieldy monster of the prehistoric ages. The broad wheels sink into the earth under the pressure; the steam hissing from the escape valves is carried by the breeze through the hawthorn hedge, hiding the red berries with a strange, unwonted cloud; the thick dark brown smoke, rising from the funnel as the stoker casts its food of coal into the fiery mouth of the beast, falls again and floats heavily over the yellow stubble, smothering and driving away the partridges and hares. There is a smell of oil, and cotton-waste, and gas, and steam, and smoke, which overcomes the fresh, sweet odour of the earth and green things after a shower. Stray lumps of coal crush the delicate pimpernel and creeping convolvulus. A shrill, short scream rushes forth and echoes back from an adjacent rick--puff! the fly-wheel revolves, and the drum underneath tightens its hold upon the wire rope. Across yonder a curious, shapeless thing, with a man riding upon it, comes jerking forward, tearing its way through stubble and clay, dragging its iron teeth with sheer strength deep through the solid earth. The thick wire rope stretches and strains as if it would snap and curl up like a tortured snake; the engine pants loudly and quick; the plough now glides forward, now pauses, and, as it were, eats its way through a tougher place, then glides again, and presently there is a pause, and behold the long furrow with the upturned subsoil is completed. A brief pause, and back it travels again, this time drawn from the other side, where a twin monster puffs and pants and belches smoke, while the one that has done its work uncoils its metal sinews. When the furrows run up and down a slope, the savage force, the fierce, remorseless energy of the engine pulling the plough upwards, gives an idea of power which cannot but impress the mind.

This is what is going on upon one side of the hedge. These engines cost as much as the fee-simple of a small farm; they consume expensive coal, and water that on the hills has to be brought long distances; they require skilled workmen to attend to them, and they do the work with a thoroughness which leaves little to be desired.

Each puff and pant echoing from the ricks, each shrill whistle rolling along from hill to hill, proclaims as loudly as iron and steel can shout, 'Progress! Onwards!' Now step through this gap in the hedge and see what is going on in the next field.

It is a smaller ground, of irregular shape and uneven surface.