To obviate the noise of the simultaneous priming of the boilers an escape valve was recently constructed, and a pipe affixed to carry it through the roof. Owing to the incapacity of the tube, however, the noise, instead of being diminished, was considerably intensified. People heard it in every quarter of the town and thought it was an explosion.

No one in the vicinity of the shed could sleep at night, so at last complaints were made to the manager, and the use of the valve was discontinued.

Now the oil furnaces will have been lit up and the smiths' forges kindled. The two foremen will have arrived and made their first perambulation of the shed, and everything will be in a state of bustle and confusion. Certainly the sparks will not be flying, nor the anvils ringing yet. It will take fully twenty minutes to get everything into order and to produce the first heat. But there is a deadly earnestness evident all round. It will not be long before the busy t.i.tans are stripped to the waist, turning the ponderous ingots and blooms over and over, and raining the blows upon the yielding metal.

The oil forge hails from the other side of the Atlantic, and is an innovation at the shed. It is attached to machinery of the American type, and is well suited for the game of hustle. It is not very large, and occupies but a small s.p.a.ce anywhere, but it has this advantage, that it may be moved to any position; it is not a fixture, as are the other furnaces. It is oblong in shape, with an arched roof; and the heating s.p.a.ce is not more than several cubic feet. The front is of brick, with as many apertures as are required for the bars of metal, and the back and ends are enclosed in a stout iron frame. The oil--derived from water-gas and tar--is contained in a tank as high as the roof, fixed outside the shed, and is conducted through pipes to the furnace. A current of air from the fan blows past the oil-c.o.c.k and drives the fluid into the furnace. The heat generated from combustion of the oil is regular and intense; the whole contrivance is speedy and simple.

This is so, however, only when the oil is good and clear. Then there will be scarcely any smoke or fume. The slight flame emitted from the vent-hole on top will be of a copperish colour, and the interior will glitter like a star. The furnace will go right merrily; there will be no need for the workman to wait a moment. But when the oil is cheap and inferior, or absolutely worthless--as it often is at the shed--the system is a most foul and abominable nuisance. As soon as the forger attempts to light up in the morning, tremendous clouds of black, filthy smoke pour out of every little crack and hole and mount into the roof.

After striking against the boards and rafters this beats down to the ground again and rolls away up the shed, filling the place from end to end, half suffocating the workmen with the sickening, disgusting stench, and making their eyes smart and burn. Several times during the operation of lighting up, by reason of the irregular flow through the feeder, the oil in the furnace will explode with a loud bang, shooting out the flames and smoke to a great distance, and frequently blowing the whole front of the forge to pieces, to the great danger of the stampers and the amus.e.m.e.nt of the other workmen and smiths--for the oil system of heating is not at all popular with the men of the shed.

The stampers' furnaces, to the number of five or six, are behaving in the same manner, and as there are no chimneys to carry off the smoke the whole smother is poured out into the shed. This will very soon be more than the average man can stand. With loud shouts and curses, down go hammers and tools; the blast is shut off from the fires and a rush is made for the open air until the nuisance is somewhat abated. The overseer walks round and round, viewing the scene with great ill-temper, defending the oil and the furnaces, and blaming the lighters-up for everything, at the same time darting angry looks at those who, half suffocated, have sought refuge outside. So, no matter what the time of year may be, whether summer or the dead of winter, when the chilling winds drive through upon the stampers shivering at their fires, he has every door and window thrown open, and often does it himself and stands like a sentinel in the doorway, that no one shall close them up till he is quite satisfied. If he moves away and the half-frozen workmen steal along and adjust the doors, he returns, closes them entirely, and forces the stampers to endure the whole smother, because they dared to meddle with the doors when he had opened them.

By and by, as the heat in the furnaces increases, the smoke will diminish somewhat, though as long as the oil is inferior they will continue to emit a dirty cloud accompanied with deadly fumes and intense volumes of heat, which are forced out by the blast to a distance of several yards, making it impossible for the youth to get near enough to attend to his bars without having his arms and face scorched and burnt.

The roof and walls, for a great distance around, are blackened with the soot. There is no mistaking the cause of it, though it is a favourite recommendation of the oil furnaces that they consume every particle of their vapour. When the oil is of a sufficiently good quality this actually happens; it is only when the fuel is cheap and bad that considerable unpleasantness arises.

Our entry to the shed was made through the large door in the north-west corner, near which the first oil furnace is situated. This furnace is attached to a new kind of forging machine conveniently named the "Ajax,"

by reason of its great strength. Ajax was the name of two of the mighty ones who fought before Troy, but the manufacturer does not inform us whether the machine is named after Ajax, the son of Telamon, or he that was the son of Oileus, though perhaps the latter is intended. Standing alongside the oil furnace is the first of the drop-stamper's forges, and next to that, in a line, are the three drop-stamps themselves. Opposite the Ajax is the foreman's office--a two-storied building--and a little to one side, straight from the door, is a coal furnace, upon which is superimposed a large "loco" boiler. This reflects a tremendous heat all round, and, together with the furnaces and forges, makes that part of the shed, though near to the door, almost unbearably hot, so that it has come to be called "h.e.l.l Corner" by the workmen.

The line of hammers and furnaces is continued up the workshop to the far end under the wall. There also, fixed to the masonry, are the main shafting and pulleys, whirled round at a tremendous rate by the engine in the "lean-to" outside. At the end of the line stand the heavy steam-hammers and, under the wall outside, the blower house, containing machinery for forcing the air for the smiths' fires. A huge stack of coal and c.o.ke is visible through the door at the other end. A small single fan is attached to the oil furnace with the Ajax in order to supply it with air. This travels at a high rate of speed and makes a loud roar, thereby adding to the confused din of the hammers and other machinery. Standing further out in the shed is a second row of smaller steam-hammers and forges with drills, saws, shears, pneumatic apparatus, other oil furnaces, and the American stamping-hammers with their trimmers and appliances. Beyond them is an open s.p.a.ce reserved for future arrivals in the shape of manufacturing plant, and towards the south wall are two lines of powerful hydraulic machines and presses with furnaces and boilers attached for heating the plates of metal for punching and welding.

The Ajax machine operates by up-setting. It is worked by youths, one of whom heats the rods of metal, while the other sets them in the dies and presses the treadle that brings the machine head forward. As soon as the furnace is sufficiently hot fifteen or twenty bars are thrust through the brickwork in front of the forge, the lubricators are filled, the belt pulled over, and the work begins. The belts flap up and down on the pulleys with a loud noise, the cog-wheels rattle and clank, the "ram" travels backwards and forwards incessantly, clicking against the self-act, the furnace roars and the smoke and flames shoot out. When the bars are white-hot the a.s.sistant hands them along; his mate grips them and inserts them in the dies, then presses the treadle with his foot.

Immediately the steel tools close up and the ram shoots forward; in about two seconds the operation is complete. Very often the water, running continually over the tools to keep them cool, becomes confined in the dies as they close. The heat of the iron converts it into steam, and, as the ram collects and forces the material, it explodes with a loud report, almost like that of a cannon. Showers of sparks and hot scale are blown in all directions, and if the operator is not careful to stand somewhat aside, his face and arms will be riddled with the tiny particles of shot-like metal ejected by the explosion. It is not uncommon to see his flesh covered with drops of blood from the accident.

The bits of metal will adhere tightly underneath the skin, and must be removed with a needle, or otherwise remain till they work out of their own accord.

Both youths of the Ajax dwell in the town, and are known about the corner by the names of Harry and Sammy. Harry's father was an infantryman, and Sammy's parent served in the Navy. There is a little of the roving spirit about both of them--each possesses a share of the paternal characteristic. Harry's father, however, is an invalid, and he is forced to stay at home and help keep him and his mother, otherwise he would long ago have bidden farewell to the shed, Ajax and all. Sammy, on the other hand, is free and unfettered, but though he has made many attempts to enter the Navy, they were all in vain. First, he was not sufficiently tall or broad in the chest, and later, when, after a course of exercises with dumb-bells, he was able to pa.s.s the examinations, he was refused on account of his teeth, which were badly decayed. This was a great disappointment to Samuel. He sulked about for several days afterwards, quarrelled and fought with his mate, and was generally inconsolable. The boys' chargeman had to intervene as peacemaker and he comforted Sammy, who shed a few tears and finally became reconciled to the forge again, though he often defiantly affirmed that he would not be beaten, not he! He would go to Bristol and get a job aboard ship; he would not stop there in that hole all his life!

Both Sammy and Harry dress much alike, and they resemble each other in their habits. They are both nimble and strong, active, energetic, and high spirited. Both have commendable appet.i.tes, and they are especially fond of drinking tea. They have a pa.s.sionate regard for sports, including boxing and football, but, over and above all this, they are hard workers; every day they are sure of a good sweating at the furnace and Ajax. Both wear football shirts--Sammy a green one and Harry a red and white--in the forge, and they have football boots on their feet. If you should turn out Sammy's pockets you would be sure to find, among other things, half a packet of cigarettes, a pack of cards, a mouth organ, a knife, a comb, and a small portion of looking-gla.s.s. A great many of the town boys and young men carry a small mirror in their pockets, by the aid of which they comb and part their hair and study their physiognomies. At meal-times, as soon as the hooter sounds, they hasten to the nearest water-tap, give their faces a rough swill and, with the aid of a portion of looking-gla.s.s, examine them to make sure that they are free from the dust and soil of the smoky furnace.

Though the companions of Ajax work hard and perspire much they do not become very tired, apparently, for after the most severe exertions they are still ready to indulge in some sport or other, and run and play or wrestle and struggle with each other on their way down the yard. Arrived home they have their tea, wash and change, and come back to the crowded parts of the town to see and be seen and be moved on by the policeman, returning late home to bed. In the morning they will often be sullen and short-tempered. This invariably wears off as the day advances, however, and they will soon be up to the usual games, singing popular songs and imitating the comic actors at the theatre, where they delight to go once or twice a week.

Close behind the oil furnace, in a recess of the wall, is the fan that drives the blast for this part of the shed, supplying four forges altogether. The fan itself is of iron, enclosed in a stout cast-iron sh.e.l.l or case, and is driven from a countershaft half-way up to the main shafting. Multiplication takes place through this from the top pulley, and whereas the main shaft will make but one hundred and twenty revolutions a minute, the fan below will, in that s.p.a.ce, spin round two thousand times. As the engine is running day and night, for more than twenty hours out of the twenty-four, the number of revolutions made by the fan will be over two millions daily. Although, viewed on paper, these figures appear high, yet, if you should stand near and watch the fan itself, it would seem incredible to you that it would require such a long time in which to complete them. The speed is terrific, and this you may know by the sound, without troubling to look at the gear. The rate of the belts, from the pulleys on to the countershaft, is a further proof of the tremendous velocity of the machine. Although strained very tight on the wheels they make a loud noise, flapping sharply all the while; one may easily gauge the speed of an engine by the sound of the belts alone. The fan itself, at normal times, emits a loud humming noise, like that of a threshing-machine, but when the speed of the engine increases through the relaxation of some other machinery, or the sudden rise of steam pressure in the boilers, it seems to swell with a dreadful fury, and a.s.sails the ear with a vicious and continuous _hoo-hoo-hoo-hoo-hoo, HOO-HOO-HOO-HOO-HOO_, like some savage beast ravenous for its prey. The oscillation of the fan is imparted to everything around. The very ground under your feet trembles, and if you should place your hand upon the outer sh.e.l.l, or on the wooden guard around it, you would experience something like an electric shock, strangely pleasant at first, but very soon necessitating the removal of your hand from the vicinity.

It is dangerous to meddle with the fan while it is in motion. A stout wooden guard is erected around it to prevent any object from coming into contact with the wheels or the interior. If a nut or rivet head should happen to fly and be caught in it, the sh.e.l.l would immediately burst.

Very often excessive speed alone will cause a fan to explode. The effect is similar to that of a steam or gas explosion; the heavy cast-iron frame will be shattered to bits, and hurled to a great distance. I remember one in the smithy that exploded and blew up through the roof, making a huge rent. For safety's sake the fans are often constructed underground in order to lessen the danger of explosion, if one should happen.

It is remarkable that while the pulley on the countershaft is travelling at a tremendous speed, so that the spokes are generally invisible, and there appears to be nothing but the rim and centre whirling round, if you look up quickly you will see one spoke quite plainly as it flies over, then it will be entirely lost to view with the rest. The s.p.a.ce of time during which it is visible is exceedingly short--it could be no more than a fraction of a second--yet in that brief period the eye perceives it clearly and distinctly: it is something similar to taking a snapshot with a camera.

Formerly, when all the belts were of leather and thickly studded with large broad-headed copper rivets, the boys used to draw near to them and take small lessons in electricity. This could only be done in the case of belts that travelled at a very high rate of speed, such as the one on the fan or the circular saw. Standing dangerously near the wheels they held a finger, or a knuckle, very close to the belt in motion, and were rewarded with seeing a small stream of electric sparks, about as large in volume as the stem of a needle, issuing from the finger-tip or knuckle, accompanied with a slight pain like that produced by the p.r.i.c.k of a pin. The velocity of the belt, with the copper, attracted the electricity within the body and drew it out in a tiny visible stream from the flesh. All the belts for high speed work at this time, however, are made of another material, _i.e._, a preparation of compressed canvas, without rivets. Instead of being laced together they are fitted with a steel-wire arrangement for connection. The ends are inserted, as you would bend the fingers of both hands and thrust them one between the other, and a piece of whalebone is pushed through. Slight as this may seem to be, it is yet capable of withstanding a great strain, and the whole runs much more smoothly than did the old-fashioned leather belts.

A man is specially kept to attend to everything pertaining to the belts.

He is known to all and sundry as the "strappie." Directly anything goes wrong with the connections he appears on the scene smothered in oil from head to foot, and looking very cloudy and serious. He is usually in a great hurry and is not over-polite to anyone. First of all he gives the signal to have the engine stopped. As soon as the shafting is still, armed with a very sharp knife, he climbs up the wall, in and out among the wheels, and unceremoniously cuts away the defective belt. Arrived on the ground again, he draws out the belt, motions "right away" to the engineman, then rolls it up and disappears. In a short while he comes back with it strongly repaired, or brings a new one in place of it. The shafting is stopped again, and up he mounts as before. When he has placed it over the shaft and connected the ends, he pulls it half-way on the wheels and ties it loosely in that position with a piece of cord. As the engine starts the belt a.s.sumes its position on the wheel automatically; the piece of cord breaks, or becomes untied, and falls to the ground, and everything goes spinning and whirling away as before. If a belt is merely loose the strappie brings a potful of a substance he calls "jam," very resinous and gluey, some of which he pours on the wheel and belt while in motion. This makes the belt "bite," or grip well, and brings the machine up to its maximum speed with the shafting.

Sometimes, if the shafting has not been oiled punctually, it will run hot, or perhaps a small particle of dust will obstruct the oil in the lubricator and produce friction. News of this is soon published abroad by a loud creaking noise that everyone can hear. The workmen take up the cry and shout "Oil, oil," at the top of their voice; then the engine-driver comes forth with his can and stops the screeching.

Occasionally the spindle of the fan will run hot, and especially so if the belt happens to be well tight. This, by reason of its great speed, will soon generate a fierce heat; I recently ran to attend to it and found the spindle of the fan a bright red-hot. Thanks to the warning of the belt, which was slipping owing to the greater exertion required through tightening of the bearings by expansion, I was just in time to prevent an accident. In another moment the fan might have been a total wreck.

Through a doorway in the wall, in an extension of the shed, stand several boilers used as auxiliaries, and, near to them, are two powerful pumping engines and their acc.u.mulators, which obtain the pressure for the whole hydraulic plant of the department. The engines are of a hundred and twenty horse-power each, and are fitted with heavy fly-wheels that make forty revolutions a minute at top speed. These draw the water from a neighbouring tank and force it into the acc.u.mulators, from which the pressure is finally derived. The acc.u.mulators are constructed in deep pits that are bricked round and guarded with iron fencing. They are large weights of fifty tons each--there was originally one of a hundred tons--and are built about a central column of iron or steel standing fifteen or twenty feet above the floor level. Contained in the lower part of the weight is a cylinder; into this the water is forced by the engines and the pressure obtained. The power of the water, when a sufficient volume has acc.u.mulated, raises the weights high into the roof and keeps them there, with a little rising and falling, corresponding to the action of the presses in the shed. When the weights have risen to a certain point they operate a self-act, and the engines stop. Similarly, when they sink below the point they displace a second small lever that communicates with the engine valves and re-starts the pumps. The pressure put on the water is enormous; it often amounts to two thousand pounds per square inch. Since the operation of water is much slower than that of steam, however, the power is not nearly as effective. It would be impossible by its agency to drive machinery at a high rate without the use of gear, though for punching, pressing, and welding some kinds of work the system is admirable and unsurpa.s.sed.

The engine that drives the lesser machinery of the shop stands in a "lean-to" and is not nearly as powerful as are those that operate the pumps. A little higher up, in another small lean-to, is a donkey engine that drives the "blower," which produces blast for the forges and fires.

This machine is vastly superior to the old-fashioned fan, and the speed of it is quite low; there is no danger of explosion or other rupture. It is a pleasure, since so much manufacturing plant is introduced to us from foreign countries--America, France and Germany--to reflect that the idea of the blower is English. There is a considerable amount of American-made machinery at the works, and the percentage of it increases every year, though it is often far from being successful. At the same time, it must be conceded that our kinsmen over the sea are very clever in the designing and manufacture of tools and plant, and many of their ideas are particularly brilliant. The English maker of manufacturing tools follows at some little distance with his wares. These, though not actually as smart as the others, are yet good, honest value, the very expression of the Englishman's character. The chief features of American machinery are--smartness of detail, the maximum usefulness of parts, capacity for high speed and flimsiness, styled "economy," of structure: everything of theirs is made to "go the pace." English machinery, on the other hand, is at the same time more primitive and c.u.mbersome, more conservative in design and slower in operation, though it is trustworthy and durable; it usually proves to be the cheaper investment in the long run. One often sees American tackle broken all to pieces after several years' use, while the British-made machine runs almost _ad infinitum_.

At a manufactory in Birmingham is an old beam engine that has been in use for more than a century and a half, and it is almost as good now as when it was new. The same may be said with regard to English-made agricultural machinery. A modern American mower will seldom last longer than four or five years, but I know of English machines that have been in use for nearly thirty years and are as good as ever, generally speaking.

One man attends to the engines that drive the shop machinery and the "blower." It is his duty to see that the shafting is kept clean and the bearings well oiled, to watch over the belts and to notify the strappie when one becomes loose or slips off the wheel. Dressed in a suit of blue overalls, and equipped with ladder and oil-can, he remains in constant attendance upon his engines and shafts. He will also be required to keep a watchful eye upon the valves, to regulate the steam to the cylinders, and to maintain a uniform rate of speed for the lathes and drills.

Occasionally, if the pressure of steam in the boilers should rise very suddenly--which sometimes happens, as the result of a variable quality of coal and the diversity of heats required by the furnacemen--the engine, in spite of the regulators, will rapidly gain speed and "run away," as it is called. This may also result from the disconnecting a particular machine engaged on heavy, dragging work, such as the saw, or fan, both of which require great power to drive them at their high rate of speed.

Considerable danger attaches to the running away of an engine, especially where it is provided with a heavy fly-wheel. This, if it is whirled round at an excessive speed, is liable to burst, and the consequences, in a crowded quarter, would be disastrous. The danger of bursting lies in the tremendous throwing-off power generated from the hub of the wheel, about the shaft; as the sections forming the circle of the wheel are brought rapidly over there is a strong tendency for them to be cast off in the same manner as a stone is thrown from a sling. If the wheel is exactly balanced, however, and every part of precisely the same weight, so as to ensure perfectly even running on the shaft, the danger of bursting will be small. Grindstones burst much more commonly than do metal wheels. There is not the same consistency in stone as in iron; moreover, there may be a flaw somewhere that has escaped the eye of the fitter or overseer. Consequently, if the speed of the engine driving the stone should be immoderately increased, it will not be able to withstand the throw-off, and will fly to pieces, inflicting death, or very severe injuries upon all those in the vicinity.

CHAPTER X

STAMPING--THE DROP-HAMMER STAFF--ALGY AND CECIL--PAUL AND "PUMP"--"SMAMER"--BOILERS--A NEAR SHAVE

The drop-stamps stand in the corner, close under the wall. They are supplied by three c.o.ke forges, and by the coal furnace before mentioned.

A drop-stamp, or drop-hammer, is a machine used for stamping out all kinds of details and uses in wrought iron or steel, from an ounce to several hundredweights. It differs from a steam-hammer properly so called in that while it is raised by steam power it falls by gravity, striking the metal in the dies by its own impetus, whereas the steam-hammer head is driven down by a piston. Three hands are employed at each machine. They are--the stamper, his hotter, and the small boy who drives the hammer. A similar number compose the night shift; the machines are in constant use by night and day. All the work is done at the piece rate, and the prices are low; the men have to be very nimble to earn sufficient money to pay them for the turn.

The hands employed on the drop-hammers are of a fairly uniform type, though there are several distinguished above the others by reason of their individual features and characteristics. Chief among them are the two young hammer boys, Algy and Cecil, Paul the furnaceman, and a youth who rejoices in the preposterous nickname of "Pump." Algy drives the end drop-stamp for the chargeman and Cecil the next one to it, larger and heavier. Algy has several nicknames, one of which, from his diminutive stature, being "Teddy Bear," and the other, carrying with it a certain amount of sarcasm, is plain "Jim." Sometimes, also, he is called "Dolly"

or "Midget." Cecil boasts of a string of christian names, the correct list being Cecil Oswald Clarence. Questioned concerning the other members of the family he informs you that his brother is named Reginald Cuthbert, his schoolgirl sister May Alberta, and his baby sister Ena Merle. From some cause or other he himself has not obtained a regular nickname; he is rather summarily addressed by his surname. No one in the shed ever deigns to call him by his christian name, it is too unusual and high-sounding, too aristocratic and superb. Bob or Jack would have been preferable; scarcely anyone at the works goes beyond a monosyllable in the matter of names.

The boys are of the same age--fifteen or thereabout--but they are dissimilar in stature and in almost every other respect. Algy is short and small, plump and st.u.r.dy, while Cecil is inclined to run. He is tall for his age, and very thin. His body is as flat as a man's hand; he has no more substance than a herring. Algy's features are round, regular, and pleasant; he is quite a handsome boy. His forehead slopes a little, his nose is perfect in shape. He has frank, grey eyes sparkling with fun and good-nature, a girlish mouth, and small, pretty teeth. Cecil, on the other hand, is not what one would style handsome. He has thin, hollow cheeks and small, hard features. His forehead is narrow, and his eyes are rather large and searching--expressing strength and keenness. His mouth is stern, and his lips pout a little: they are best represented by the French _s'allonger--les levres s'allongent_, as Monsieur Jourdain's did in Moliere, when he p.r.o.nounced the vowel sound of u. He has a particularly fine set of teeth, and he has a way of grizzing them together and showing them when in the act of making a special exertion that gives him a savage expression.

Both boys are pale. Algy's face, when it is clean, shines like a gla.s.s bottle; Cecil's skin is inclined to be yellow. Both have dark rings around the eyes, especially Cecil, who is the more delicate of the two--they are neither very robust-looking. Their hair is very long, and it stands out well from underneath their cloth caps and stretches down the cheeks before the ears. They are consequently often a.s.sailed with the cry--"Get yer 'air cut," or--"You be robbin' the barber of tuppence," or--"Tell yer mother to use the basin," suggesting that the boys' hair is cut at home. It is a common charge to lay to small boys in the shed that their mothers used to put a basin over their heads and cut the hair around the outside of it. Both boys wax indignant at being taunted about the basin, and reply to the other remark with, "You gi' me the tuppence, then, an' I'll have it cut." Occasionally, more by way of being sarcastic than out of any desire to show good-nature, the stampers will make a collection towards defraying the barber's expenses, and the next morning the boys will turn up at the shed nearly bald: they have had their hair cut this time with a vengeance.

Several times Algy has come to the shed wearing a pair of wooden clogs, but, as everyone teased him and called him "Cloggy," he cast them aside and would not wear them any more. Clogs belong rather to the Midlands and the North of England, and are very rarely seen in the railway town.

The least respectable of all the boys' clothing are their shirts. They are usually full of big rents, being split from top to bottom, or torn quite across the back, the lower part falling down and exposing the naked flesh for a s.p.a.ce of a foot, and they are of an inscrutable colour. One day an entire sleeve of Algy's shirt dropped clean away, and Cecil's was rent completely up one side so that his entire flank and shoulder were visible. Though the stampers laugh at Cecil and sometimes grip hold of whole handfuls of his flesh, where the shirt is torn, he is not very much disconcerted. Algernon blushed considerably, however, when his mate quietly told him one day that he could see his naked posterior through a rent in his trousers.

Although the boys' clothing is untidy and dilapidated they are not kept short of food, and their appet.i.tes are truly enormous. They bring large parcels of provisions to the shed--thick chunks of bread and b.u.t.ter, rashers of raw bacon, an egg to boil or fry, and sometimes a couple of polonies or succulent sausages. The whole is tied up in a red dinner-handkerchief or wrapped in a newspaper; you would often have a difficulty in getting it into an ordinary-sized bucket. The youngsters have to stand a great deal of chaff over their parcels of provisions.

The men often take them in their hands and weigh them up and down, showing them about the shed, and asking each other if they do not want to buy a pair of old boots. At breakfast- or dinner-time the lads obtain a roughly-made frying-pan, or take the c.o.ke shovel, and, after rubbing it out with a piece of paper, cook their food, usually frying it together and dipping their bread in the fat alternately. Then, if it is fine, still stripped of their waistcoats, they go out in the yard and sit down, or crouch by the furnace door and clear up the food to the last morsel; they will often not have finished when the hooter sounds the first time to warn the men to come back to the shed. When the meal is over, if there is yet time, Algy will produce from his pocket some literature of the Buffalo Bill type, or a school story, of which he is fond, and read it. Cecil will not deign to look at "such stuff," as he calls it, but will borrow a newspaper, or some part of one, from his mates, and greedily devour the contents of that.

Though neither of them has left school for more than a year, or, at the outside, fifteen months, they have forgotten almost everything they learned, even to the very rudiments in many cases. Their knowledge of grammar, arithmetic, poetry, geography, and history has entirely lapsed, or, if they remember anything at all, it will be but a smattering of each. To test their memory and knowledge of these matters the boys'

chargeman occasionally offers them prizes, and enters them into compet.i.tion with other lads of the shed, some of whom have not been away from school for more than five or six months, but one and all show a deplorable lack of the faculty of retention. Whether it is the result of too much cramming by the teacher, or whether it is that the rising generation is really deficient in mental capacity, they are quite incapable of answering the most simple and elementary questions. The chargeman's plan is to offer them pennies for the names of half-a-dozen capitals of foreign countries, half-a-dozen foreign rivers, six names of British kings or British rivers, the capitals of six English counties, or the names of the counties themselves, six fish of English rivers, six wild birds, half-a-dozen names of wild flowers, the capitals of British colonies, the names of six English poets, or a few elementary points of grammar, and so on.

The answers, when any are vouchsafed, are often ludicrous and amazing: the intellectual capacity of the boys is certainly not very brilliant.

During these tests the chargeman was astonished to learn that Salisbury is a county, Ceylon is the capital of China, and that Paris stands on the banks of the river Liffey. As for the preterite tense, not one had ever heard of it. Only one out of six could give the names of the six counties and kings complete, though another of the lads had strong impressions concerning a monarch he called the "ginger-headed" one, but he could not think of his name. Not one could furnish the requisite list of fish, fowl, and natural wild flowers, but little Jim, struck with a sudden inspiration, shouted out "jack and perch," for he had recently been fishing in the clay-pits with his brother. The others frankly confessed they did not know anything about the matter; if they had ever learned it at school they had forgotten it now. Anyway, it was not of much use to one, they said, though it was all right to know about it.

Not one of the half-dozen, though all were born in the town, could give the name of a single Wiltshire river.

Paul is not permanently attached to the furnace in the corner, but came to fill the place of one who had met with an accident. As a matter of fact, Paul is everybody's man; he is here, there, and everywhere. He can turn his hand to almost anything in the second degree, and is a very useful stop-gap. Forge he cannot, stamp he cannot, though he is a capital heater of iron, and makes a good furnaceman; he is a fair all-round, inside man. But somehow or other, everyone persists in making fun of Paul, and contrives to play pranks and practical jokes upon him.

Whatever job he is engaged upon his mates address ridiculous remarks to him; they will never take him seriously. Some one or other, in pa.s.sing by, will knock off his hat; this one gravely takes him by the wrist and feels his pulse, and that one will give him a rough push. Another puts water over him from the pipe, pretending it was by accident; whatever reply he makes his mates only laugh at him. As a rule, Paul takes it all in good part, though sometimes he will lose his temper and retaliate with a lump of coal, or any other missile upon which he can lay his hands.

Paul would be the tallest man in the shed if it were not that he stoops slightly as the result of having had rheumatics. As it is, he is quite six feet in height, bony, but not fleshy, with broad shoulders and large limbs. As he walks his head is thrown forward; he goes heavily upon his feet. His features are regular and pleasant; he has grey eyes and bushy brows. His skin is dark with the heat and grime of the furnace; his expression is one of marked good-nature. In appearance he is a perfect rustic; there is no need to look at him the second time to know that he dwells without the munic.i.p.al border. It is this air of rusticity, combined with his simplicity of character and behaviour, that makes Paul the b.u.t.t of the other workmen. They would not think of practising their clownish tricks upon others, for there are many upon whom it would be very inadvisable to attempt a jest without being prepared for a sudden and violent reprisal.

Paul's home is in the village, about three miles from the town. There he pa.s.ses his leisure in comparative quiet, and, in his spare time from the shed, cultivates a large plot of land and keeps pigs. This finds him employment all the year round, so that he has no time to go to the public-house or the football match, though he sometimes plays in the local cricket eleven. He takes great interest in his roots and crops, and almost worships his forty perch of garden. During the summer and autumn he brings the choicest specimens of his produce in his pocket and shows them to his mates in the shed; he usually manages to beat all comers with his potatoes and onions.

In spite of Paul's simplicity of behaviour, one cannot help being attracted to him by reason of his frankness and open-heartedness; he would not think of doing anything that is not strictly above board.

Though rough and rude, blunt and unpolished, he is yet very honest and conscientious. Certainly he is not as sharp and intelligent as are many of the town workmen, but he is a better mate than most of them, and when it comes to work he will stand by you to the last; he is not one to back out at the slightest difficulty.

How Pump came to be Pump is a mystery; no one knows the origin of the nickname. "They called I Pump a long time ago," says he. Very likely it was given to him extemporaneously, with no particular relation to anything; someone or other said "Pump," and the name stuck there at once. Pump is just under eighteen years of age. He drives the heavy drop-stamp on the day-shift, and, owing to certain characteristics of which he is possessed, he always attracts attention. He is very loud and noisy, full of strong words and forcible language, though he is extraordinarily cheerful and good-natured. He is short in stature, very strong and much given to sweating; in the least heat his face will be very red and covered with great drops of perspiration. His forehead is broad and sloping, he has immense blue eyes, tapered nose, bronze complexion, a solid, square countenance, and a tremendous shock of hair.

In driving the hammer he has acquired the unusual habit of following the heavy monkey up and down with his eyes, and the expression on his face, as he peers up into the roof, induces many to stop and take a peep at him as they pa.s.s by. To all such Pump addresses certain phrases much more forcible than polite, and warns them to "clear out" without delay if they do not "want something." They usually respond with an extra-special grimace, or work their arms up and down as though they were manipulating the engine from which he derives his nickname.